Rheem RGJF User Manual download pdf

FORM NO. G11-500 REV. 1

Supersedes Form No. G11-500

GAS FURNACES

RGGE- SERIES

Models with Input Rates

from 60,000 to 120,000 BTU/HR

[17.58 to 35.16 kW]

(U.S. & Canadian Models)

Equipped with

Comfort Control

System

™

• Serial communication enabled

• Increased system reliability and efficiency

• 28 on-board diagnostic and operating codes

•

Active Protection

™

with homeowner

“Call for Service” alert

• Dual 7-segment LED display

RHC-TST550CMMS

Modulating Furnace Thermostat

90 PLUS COMMUNICATING

MODULATING DOWNFLOW

GAS FURNACES EQUIPPED

WITH THE COMFORT

CONTROL

SYSTEM AND

CONTOUR COMFORT CONTROL

The Rheem

Prestige Series

™

90 Plus High Efficiency line of downflow gas

furnaces are designed for utility rooms, closets, or alcoves, attics or crawl

spaces.

The design is certified by CSA.

Features

■ The

Comfort Control

System™

provides over 28 on-board diagnostics

and fault history codes by detecting system and electrical problems. “Call

for Service” alert notification is sent to the thermostat to alert the home-

owner of required service.

■

Serial Communication Enhanced – When installed with a Serial Com muni -

cat ing Condensing Unit and user interface control (RHC-TST550CMMS)

500 Series thermostat this unit offers 4 or 2 wire installation, auto-configura-

tion, and diagnostic messaging with full communicating capability.

■ Heat exchanger is constructed of all stainless steel for maximum corro-

sion resistance and thermal fatigue reliability.

■ Modulating Function: when used with a modulating or communicating

thermostat, modulation rate between 40% and 100% of total capacity.

■ Two-stage Function: when used with a two-stage thermostat, furnace oper-

ates at 40% on first stage, and stages up to 65%, then 100% for second

stage.

■ Multistage Function: when used with a single-stage thermostat, furnace

functions as a three stage furnace operating at 40%, 65% and 100% of

total capacity.

■ Reduced firing rates, electrically efficient ECM2+ motor, and solid doors

provide the ultimate in quiet operation.

■ Low speed constant fan.

■ Constant temperature rise for superior comfort.

■ Seven segment LED for system diagnostics.

■ Diagnostic history for troubleshooting.

■ Two-speed induced draft motor.

■ Direct spark ignition with remote sense.

■ Top electrical connections, left or right gas and condensate drainage con-

nections on downflow models.

■ Optional indoor or outdoor combustion air.

A variety of cooling coils and plenums designed to use with the Rheem

Prestige Series

™

90 Plus gas furnaces are available as optional accessories.

✝ A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with Department of Energy test

procedures.

1 2 3 4 5 6 7 8

Summary of Contents

Page 1 - GAS FURNACES

FORM NO. G11-500 REV. 1 Supersedes Form No. G11-500GAS FURNACESRGGE- SERIESModels with Input Rates from 60,000 to 120,000 BTU/HR[17.58 to 35.16 kW](U.

Page 2 - COMFORT CONTROL

2 Rheem Heating, Cooling and Water Heating The Rheem Dual 7-Segment LED Display easily shows sys-tem operating status codes and diagnostic codes. The

Page 3 - PRESTIGE SERIES

Rheem Heating, Cooling and Water Heating 3STANDARD EQUIPMENTCompletely assembled and wired; heat exchanger; primary: 409 and aluminized409 stainless s

Page 4 - MODEL IDENTIFICATION

4 Rheem Heating, Cooling and Water HeatingBEFORE PURCHASING THIS APPLIANCE, READ IMPORTANT ENERGY COST AND EFFICIENCY INFORMATION AVAILABLEFROM YOUR R

Page 5 - DOWNFLOW MODELS

Rheem Heating, Cooling and Water Heating 5DOWNFLOW MODELSMODELRGGE-A B C D E FLEFTSIDEMINIMUM CLEARANCE (IN.) [mm]RIGHTSIDEBACK TOP FRONT VENT06171/2

Page 6

6 Rheem Heating, Cooling and Water HeatingBLOWER PERFORMANCE DATA—RGGE MODELSMODELRGGE-BLOWER SIZE(D x W)IN. [mm]ICMMOTOR H.P.[W]BLOWERSPEED(SELECTED

Page 7 - ACCESSORIES—DOWNFLOW

Rheem Heating, Cooling and Water Heating 7CONTRACTOR BENEFITS:• Multi-Purpose Thermostat-Setup, Control & Diagnostics• Auto-Configuration – No Man

Page 8 - ACCESSORIES—DOWNFLOW (con’t.)

ACCESSORIES—DOWNFLOW (con’t.)FOR HIGH ALTITUDES:RGGE HIGH ALTITUDE FIELD CONVERSION KITS:MODEL INPUT (KBTU) KIT NO.RGGE-06 60,000 None NeededRGGE-07 7

Rheem RGJF User Manual

Browse online or download User Manual for Water heaters & boilers Rheem RGJF. GAS FURNACES

Summary of Contents

More documents for Water heaters & boilers Rheem RGJF

Comments to this Manuals

Rheem RGJF User Manual

Browse online or download User Manual for Water heaters & boilers Rheem RGJF. GAS FURNACES

Summary of Contents

More documents for Water heaters & boilers Rheem RGJF

Comments to this Manuals

Related products and manuals for Water heaters & boilers Rheem RGJF